Current Classifieds

WTB: 2.0 Mech tach drive distributor
Date: 04/14/2023 06:15 am
72 pinto drag car

Date: 07/08/2017 08:53 pm
Misc pinto parts 71-73 2.0
Date: 05/05/2020 11:56 pm
Looking for Pinto manual shifter parts
Date: 01/28/2021 03:49 pm
WTB: Ford Type 9 5spd Transmission
Date: 03/18/2020 01:30 am
1979 Pinto Rear Bumper
Date: 03/26/2021 03:26 pm
Ignition switch 72 pinto wagon 2.0 4 sp
Date: 12/31/2017 09:03 pm
1978 need kick panels and rear hatch struts and upper and lower mounts
Date: 11/29/2018 10:26 am
Bumper Guards
Date: 03/28/2017 09:27 pm
Pinto porthole exterior trim wanted
Date: 03/30/2021 12:29 pm
Clutch Pedals for 75to 80 Pinto
Date: 09/21/2018 11:35 am
Wanted Type 9 5spd Transmission
Date: 07/04/2017 03:26 pm

Author Topic: Clutch Adjustment Question  (Read 1589 times)

0 Members and 1 Guest are viewing this topic.

Offline amxtra

  • Pinto Member
  • **
  • Posts: 59
  • FeedBack: +1/-0

  • Total Badges: 3
    Badges: (View All)
    Topic Starter Windows User Fifth year Anniversary
Clutch Adjustment Question
« on: August 13, 2013, 06:48:32 PM »
Been so long since I had to pay attention and not take for granted it was right I cant recall, and since its easier to ask than to pull the darn thing apart again....
Since no other T5 swap has had the clutch engagement problem Im having been working on making it work.
How far back does the fork need to sit? is halfway like in the pic ok, or do I need more travel?

Offline amc49

  • PCCA VIP
  • Pinto Master
  • ***
  • Posts: 1256
  • FeedBack: +242/-1
  • Another Pinto Driver

  • Total Badges: 4
    Badges: (View All)
    Topic Starter Poll Voter Windows User 1000 Posts
Re: Clutch Adjustment Question
« Reply #1 on: August 23, 2013, 09:55:21 PM »
More than one thing to consider there. Arm needs to be away from back of opening when clutch fully loose. Arm must also be in a position to be able to use maximum adjustment of either cable or solid linkage pushing on it. Does no good putting it in the middle of hole if then you only have very little adjustment on a new clutch. If motor is out so you can play, then bolt trans to motor and check by turning trans output while in gear, slowly move lever back until clutch releases cleanly and then a bit more and see where in opening that all ends up. You don't want a whopping amount of over travel when pushing on pressure plate, depending on the type (diaphragm) you can go too far and pressure plate then goes over center to stick and then does not come back. When fully released the arm must allow some freeplay too, maybe 1/2" at clutch pedal itself is good, otherwise the throwout bearing wears like lightning.

Now, try getting all that in one package. Fun.